2012 VOLKSWAGEN PASSAT OWNERS MANUAL PDF DOWNLOAD

Author: Felmaran Faelabar
Country: Germany
Language: English (Spanish)
Genre: Marketing
Published (Last): 2 September 2011
Pages: 412
PDF File Size: 3.80 Mb
ePub File Size: 16.33 Mb
ISBN: 771-2-23894-659-4
Downloads: 75465
Price: Free* [*Free Regsitration Required]
Uploader: Tautilar

Tightening torque remains unchanged. Install oil seal and grease cap as shown.

Rear brake caliper, servicing Page 3 of 8 2012 volkswagen passat owners manual pdf download – Brake caliper housing with parking brake cable lever If a leak exists at the parking brake cable lever replace brake caliper housing After repairing, pre- bleed caliper housing Page 8 – Guide pins Grease before pulling on protective cap Steering Page 71 of 99 Power steering gear, assembling Note: Page Steering Page 90 of 99 Power steering vane pump, removing and installing vehicles with 4- Cyl.

Steering Page 73 of 99 Toothed oassat, installing in the housing – Grease teeth of toothed rod with AOF 04 grease – Slide protective tube golkswagen toothed rod to stop – Wipe away excess grease completely No grease must get into the oil circulation system!

VOLKSWAGEN PASSAT REPAIR MANUAL Pdf Download.

Removing and installing suspension strut at body Page Tightening torque -A-: Page Steering Page 35 of 99 – Remove lower locking screw for valve body 1 – Ratchet standard commercial If very tightly seated, loosen locking screw with a hammer and driver – Remove hex nut below valve body 1 – Ratchet standard commercial 2 – Open-end wrench standard commercial – Drive valve body upward from below with driver – Remove grease from teeth of valve body Rear wheel brakes, servicing 2012 volkswagen passat owners manual pdf download brakes Page 1 of 4 Rear wheel brakes, servicing drum brakes Notes Page 1 – Grease cap Removing and installing from Page 2 – Cotter pin Always replace 3 – Locking ring 4 – Hex nut Passt wheel bearing play 2012 volkswagen passat owners manual pdf download Page 18 of 99 Installing Install in reverse order.

Page Rear wheel brakes, servicing Page 4 of 8 Fig.

Page 62 Front Wheel Suspension, Shafts 2012 volkswagen passat owners manual pdf download Axle Page 48 of 82 5 – Boot for mm diameter constant velocity joint Rubber version With vent hole Check for tears and chafing Installation position for left drive shaft Fig.

Steering Page 41 of 99 Sealing ring on toothed rod, replacing – Press pliers pddf with slight pressure on the sealing ring – Pry out sealing ring and O-ring A – Needle nose pliers standard commercial 1 – Toothed rod with piston 2 – Sealing rod 3 – O-ring http: The splines of the outer joint and the hub on Plus suspensions are secured with locking fluid D A2. Apply one drop only in 2nd thread of rack. Parking brake lever assembly overview Page 6 of 9 6 – Brake pedal return spring 7 – Dowload spring mounting tube 8 – Downoad pedal mounting bushing 9 – Brake pedal 10 – Clutch pedal Removing and installing Repair Manual, 5 Spd.

Page Rear axle, servicing four wheel drive vehicles Page 8 of 13 Fig. Steering Page 85 of 99 Assembly overview: Do not reuse drained hydraulic oil. Steering Page 40 of 99 Checking toothed rod for scoring If corroded areas or vopkswagen scratches are not noticeable on the toothed rod, the toothed rod must be replaced An 2012 volkswagen passat owners manual pdf download of whether the toothed rod was damaged by force, e.

Front brakes, servicing Girling caliper Page 7 of 7 Installing Note: Xownload and straightening of the axle beam is not permissible.

2012 VW Passat Owners Manual Pdf

Coat sealing ring with lubricant e. Page Rear drive shafts, servicing Page 3 of 7 4 – Boot for 94 mm diameter constant velocity joint Rubber version Check for tears and chafing Installation position: Steering Page 28 of 99 11 – Adjusting screw with 2012 volkswagen passat owners manual pdf download nut, 60 Nm 44 ft Before removing, mark position of adjusting bolt and lock nut on housing Steering gear, adjusting Page 12 – Pressure spring 13 – Pressure piece Mark installation position 14 – Housing Removing – Remove wheels.

Page Steering Page 14 of 99 – With engine running at idling speed. Front Wheel Suspension, Shafts and Axle Page 23 of 82 Front suspension strut, servicing Base and Plus suspension 1 – Shock absorber Can be replaced individually Check shock absorber for leaks and noises After replacing, adjust camber and toe Page 2012 volkswagen passat owners manual pdf download – Buffer stop 3 – Protective sleeve Ownrrs must be adjusted each time joint is loosened.

Page 84 Front Wheel Suspension, Shafts and Axle Page 70 of 82 Drive axle with triple-rotor joint, removing and installing Removing right-side drive axle The right drive axle removal instructions remain unchanged from the current repair manual procedure. Vehicle alignment should not be checked before the vehicle has completed to Hydraulic units supplied as replacement parts are already filled with hydraulic fluid and bled.

Steering Page 62 of 99 Note: Page Parking brake lever assembly overview Page 4 of 9 Fig. Rear wheel brakes, servicing Page 2 of 8 4 – Upper psssat spring Unhook with pliers 5 – Lower return spring Lubricate contact points with G paste 6 – Wedge spring 7 – Brake shoe 2012 volkswagen passat owners manual pdf download and installing Page Minimum lining Steering Page 14 of 99 – With engine running at idling speed.

Illustration shows the housing in cross section for better view.

Wheel bearings, servicing Page 15 of 18 Fig. Rear wheel brakes, servicing drum brakes Page 3 of 4 10 – Hex socket head bolt, 10 Nm 7 ft lb 11 – Wheel speed sensor Pvf on vehicles with Insert with lubricating paste, G 12 – Backing plate with brake shoes Release adjustment before removing brake M10 x1, 15 Nm 11 ft Page Rear wheel brakes, servicing disc brakes Page 7 2012 volkswagen passat owners manual pdf download 10 Brake pads, removing and installing Note: